Maintenance Under Severe Usage Conditions |
- For Gasoline Engine [For Europe (Except Russia)]
MAINTENANCE ITEM |
MAINTENANCE OPERATION |
MAINTENANCE INTERVALS |
DRIVING CONDITION |
Engine oil and engine oil filter |
R |
Every 7,500 km (5,000 miles) or 6 months |
A, B, C, D, E, F, G, H, I, J, K, L |
HSG (Hybrid Starter & Generator) belt |
R |
Every 45,000 km (30,000 miles) or 24 months |
C, D, E, L |
I |
Every 7,500 km (5,000 miles) or 6 months |
C, D, E, L |
|
Air cleaner filter |
R |
Replace more frequently depending on the condition |
C, E |
Spark plugs |
R |
Replace more frequently depending on the condition |
B, H, I, L |
Dual clutch transmission (DCT) fluid |
R |
Every 120,000 km (80,000 miles) |
C, D, E, F, G, H, I, K |
Steering gear rack, linkage and boots |
I |
Inspect more frequently depending on the condition |
C, D, E, F, G |
Suspension ball joints |
I |
Inspect more frequently depending on the condition |
C, D, E, F, G |
Brake discs and pads, calipers and rotors |
I |
Inspect more frequently depending on the condition |
C, D, E, G, H |
Parking brake |
I |
Inspect more frequently depending on the condition |
C, D, G, H |
Drive shaft and boots |
I |
Inspect more frequently depending on the condition |
C, D, E, F, G, H, I, K |
Climate control air filter |
R |
Replace more frequently depending on the condition |
C, E, G |
Maintenance operation
I : Inspect and if necessary, adjust, correct, clean or replace.
R : Replace or change.
SEVERE DRIVING CONDITIONS
A : Repeatedly driving short distance of less than 8 km (5miles) in normal
temperature or less than 16 km (10 miles) in freezing temperature. |
G : Driving on uphill, downhill, or mountain roads. |
B : Extensive engine idling or low speed driving for long distances. |
H : Towing a trailer or using a camper on roof rack. |
C : Driving on rough, dusty, muddy, unpaved, graveled or saltspread roads.
|
I : Driving for patrol car, taxi, commercial car or vehicle towing. |
D : Driving in areas using salt or other corrosive materials or in very
cold weather |
J : Driving in very cold weather. |
E : Driving in heavy dust condition |
K : Driving over 170 km/h (106 mile/h). |
F : Driving in heavy traffic area |
L : Frequently driving in stop-and-go conditions. |
Kia Niro 2017 (DE HEV) Service Manual: Troubleshooting
Trouble Shooting
Ignition System
Symptom
Suspect area
Remedy
Vehicle indicates Ready in dash, but engine will not run when requested
by the HPCU (HEV module).
Ignition coil
Inspect ignition coil, or repl ...
Kia Niro 2017 (DE HEV) Service Manual: Front Wheel Speed Sensor Repair procedures
Removal
1.
Remove the tire.
Tightening torque:
107.9 - 127.5 N·m (11.0 - 13.0 kgf·m, 79.6 - 94.0 lb·ft)
Be careful not to ...