Kia Niro: Hybrid Motor Control System / Resolver Sensor Repair procedures

Inspection

Hybrid Drive Motor

1.

Inspect the resolver sensor resistance.

Item
Pin
Specification
Remarks
Resistance
(Resolver sensor)
1 - 5
11.7 Ω ± 10 %
At room temperature 68°F (20°C)
2 - 6
34.5 Ω ± 10 %
3 - 7
29.5 Ω ± 10 %

2.

If the resolver sensor needs to be replaced, replace the hybrid drive motor assembly.

(Refer to Hybrid Motor Assembly - "Hybrid Drive Motor Assembly")

Hybrid Starter Generator (HSG)

1.

Inspect the resolver sensor resistance.

Item
Pin
Specification
Remarks
Resistance
(Resolver sensor)
1 - 4
13.8 - 17.8 Ω
At room temperature 68°F (20°C)
2 - 5
26.2 - 30.2 Ω
3 - 6
26.2 - 30.2 Ω

2.

If the resolver sensor needs to be replaced, replace the HSG assembly.

(Refer to Hybrid Motor Assembly - "Hybrid Starter Generator")

Resolver Calibration

Perform the resolver calibration using the KDS/GDS after replacing or reinstalling the below components.

Hybrid Drive Motor installation

Hybrid Starter Generator (HSG) installation

Motor Control Unit (MCU) replacement

Engine clutch system replacement

Resolver Sensor Schematic diagrams
Part Circuit Diagram [Hybrid Drive Motor] [HSG] ...

Motor Temperature Sensor Description and operation
Description Temperature of the motor largely influences the motor output. Hence, when the motor is overheated, major components such as the IPM or stator coil may get damaged or affec ...

Other information:

Kia Niro (DE HEV) Owners Manual: Automatic heating and air conditioning
1. Press the AUTO button. The modes, fan speeds, air intake and air-conditioning will be controlled automatically according to the temperature setting. 2. Turn the temperature control knob to the desired temperature. ✽ NOTICE To turn the automatic operation off, select any button or sw ...

Kia Niro 2017 (DE HEV) Service Manual: Mode Control Actuator Repair procedures
Inspection 1. Switch "OFF" the ignition. 2. Disconnect the mode control actuator connector. 3. Verify that the mode control actuator operates to the defrost mode when connecting 12V to terminal 3 and ground ...

© 2016-2024 www.kniro.net