Kia Niro: Body (Interior and Exterior) / Troubleshooting
Kia Niro 2017 (DE HEV) Service Manual / Body (Interior and Exterior) / Troubleshooting
| Troubleshooting |
|
Symptom |
Suspected Area |
Remedy |
|
Water leaks from panorama sunroof |
Deteriorated roof lid weatherstrip |
Replace |
|
Excessive roof lid-to-body clearance and improperly fitted weatherstrip
|
Adjust |
|
|
Wind noise around panorama sunroof |
Loose or deformed deflector, gaps in body work |
Retighten adjust or replace |
|
Noise heard when opening/closing panorama sunroof |
Foreign particles lodged in guide rail |
Check drive cable and guide rails for foreign particles |
|
Loose guide rails and lid |
Retighten |
|
|
Motor runs but sunroof does not move or moves only partially |
Foreign particles lodged in guide rail |
Adjust or replace |
|
Incorrect engagement of motor pinion with drive cable |
||
|
Decrease in motor's clutch slipping force |
||
|
Increased sunroof sliding resistance or interference of sunroof with drive
cables, weatherstrip, etc. due tomal adjustment of sunroof |
||
|
Noise in motor (clutch slipping noise from motor when sunroof is fully opened
or closed) is considered as normal |
Incorrect engagement of motor pinion with drive cable |
Check pinion installation and Re-tighten motor |
|
Worn out or damaged motor pinion bearing |
Replace motor assembly |
|
|
Worn out or deformed drive cable |
Replace |
|
|
Door glass fails to operate up and down |
Incorrect window glass installation |
Adjust position |
|
Damaged or faulty regulator arm or regulator |
Correct or replace |
|
|
Door does not open or close completely |
Incorrect door installation |
Adjust position |
|
Defective door check assembly |
Correct or replace |
|
|
Door hinge requires grease |
Apply grease |
|
|
Hood does not open or close completely |
Striker and latch not properly aligned |
Adjust |
|
Incorrectly installed hood |
Adjust |
|
|
Incorrect hood bumper height |
Adjust |
|
|
Water leaks through windshield end rear window |
Defective seal |
Fill with sealant |
|
Defective flange |
Correct |
Special service tools
Special Service Tools
Tool (Number and name)
Illustration
Use
09880-4F000
Hog ring clip installer
...
Other information:
Kia Niro (DE HEV) Owners Manual: Passenger’s front air bag ON/OFF switch
The passenger’s front air bag can be deactivated by the passenger’s front air
bag ON/OFF switch if a child restraint is installed on the front passenger's seat
or if the front passenger's seat is unoccupied by a person.
To ensure the safety of your child, the passenger’s front a ...
Kia Niro (DE HEV) Owners Manual: Virtual Engine Sound System (VESS)
The Virtual Engine Sound System generates an engine sound for pedestrians to
hear vehicle while at low speeds in EV mode.
Hybrid battery air intake
The hybrid battery air intake is located on bottom the rear seats. The air intake
cools down the hybrid battery. When the hybrid battery air int ...
© 2016-2026 www.kniro.net
