Kia Niro: Crankcase Emission Control System / Repair procedures

Inspection
1.

After disconnecting the vapor hose from the PCV valve, remove the PCV valve.

2.

Reconnect the PCV valve to the vapor hose.

3.

Run the engine at idle, then put a finger over the open end of the PCV valve and make sure that intake manifold vacuum can be felt.

  

The plunger inside the PCV valve will move back and forth in vacuum.

4.

If the vacuum is not felt, inspect PCV operation. If operating correctly, clean or replace the vapor hose.

Schematic diagrams
Schematic Diagram ...

Positive Crankcase Ventilation (PCV) Valve Description and operation
Operation Principle ...

Other information:

Kia Niro 2017 (DE HEV) Service Manual: Hood Latch Repair procedures
Replacement 1. Remove the front bumper cover. (Refer to Front Bumper - "Front Bumper Cover") 2. Disconnect the hood lower latch connector (A). 3. Remove the engine clutch reservoir (A) after looseni ...

Kia Niro 2017 (DE HEV) Service Manual: Rear Door Side Weatherstrip Repair procedures
Replacement 1. Loosen the rear door checker (B) mounting bolt. Tightening torque : 19.6 - 29.4 N·m (2.0 - 3.0 kgf·m,14.5 - 21.7 lb·ft) 2. Detach the clips, and remove the rear door side weather ...

© 2016-2020 www.kniro.net